Gas Turbines: Microturbines and Small Turbomachinery

Use of Low/Mid-Temperature Solar Heat for Thermochemical Upgrading of Energy, Part I: Application to a Novel Chemically-Recuperated Gas-Turbine Power Generation (SOLRGT) System

[+] Author and Article Information
Na Zhang1

Institute of Engineering Thermophysics,  Chinese Academy of Sciences, Beijing, 100190, P. R. C.zhangna@mail.etp.ac.cn

Noam Lior

Department of Mechanical Engineering and Applied Mechanics,  University of Pennsylvania, Philadelphia, PA 19104-6315


Corresponding author.

J. Eng. Gas Turbines Power 134(7), 072301 (May 23, 2012) (14 pages) doi:10.1115/1.4006083 History: Received January 21, 2012; Revised February 01, 2012; Published May 23, 2012

This paper is the first part of a study presenting the concept of indirect thermochemical upgrading of low/mid temperature solar heat, and demonstration of its integration into a high efficiency novel hybrid power generation system. The proposed system consists of an intercooled chemically recuperated gas turbine (SOLRGT) cycle, in which the solar thermal energy collected at about 220 °C is first transformed into the latent heat of vapor supplied to a reformer and then via the reforming reactions to the produced syngas chemical exergy. The produced syngas is burned to provide high temperature working fluid to a gas turbine. The solar-driven steam production helps to improve both the chemical and thermal recuperation in the system. Using well established technologies including steam reforming and low/mid temperature solar heat collection, the hybrid system exhibits promising performance: the net solar-to-electricity efficiency, based on the gross solar thermal energy incident on the collector, was predicted to be 25–30%, and up to 38% when the solar share is reduced. In comparison to a conventional CRGT system, 20% of fossil fuel saving is feasible with the solar thermal share of 22%, and the system overall efficiency reaches 51.2% to 53.6% when the solar thermal share is increased from 11 to 28.8%. The overall efficiency is about 5.6%-points higher than that of a comparable intercooled CRGT system without solar assist. Production of NOx is near zero, and the reduction of fossil fuel use results in a commensurate ∼20% reduction of CO2 emissions. Comparison of the fuel-based efficiencies of the SOLRGT and a conventional commercial Combined Cycle (CC) shows that the efficiency of SOLRGT becomes higher than that of CC when the solar thermal fraction Xsol is above ∼14%, and since the SOLRGT system thus uses up to 12% less fossil fuel than the CC (within the parameter range of this study), it commensurately reduces CO2 emissions and saves depletable fossil fuel. An economic analysis of SOLRGT shows that the generated electricity cost by the system is about 0.06 $/kWh, and the payback period about 10.7 years (including 2 years of construction). The second part of the study is a separate paper (Part II) describing an advancement of this system guided by the exergy analysis of SOLRGT.

Copyright © 2012 by American Society of Mechanical Engineers
Your Session has timed out. Please sign back in to continue.



Grahic Jump Location
Figure 1

Indirect upgrading the low/mid level solar heat

Grahic Jump Location
Figure 2

Schematic diagram of the basic CRGT cycle

Grahic Jump Location
Figure 3

Schematic diagram of the SOLRGT cycle

Grahic Jump Location
Figure 4

Heat recuperation T-Q diagram for the IC-CRGT system

Grahic Jump Location
Figure 5

Heat recuperation T-Q diagram for the SOLRGT system

Grahic Jump Location
Figure 6

Comparison of thermal performance with CC

Grahic Jump Location
Figure 7

The impact of solar thermal share Xsol on solar-to-electricity efficiency ηsol , and fossil fuel saving ratio SRf

Grahic Jump Location
Figure 8

The impact of solar thermal share Xsol on system efficiency ηe and specific net power output Wnet

Grahic Jump Location
Figure 9

The replacement of fossil fuel energy by solar thermal energy/exergy, Rf and Rfe

Grahic Jump Location
Figure 10

System performance comparison

Grahic Jump Location
Figure 11

Parametric sensitivity analyses of electricity cost COE

Grahic Jump Location
Figure 12

Parametric sensitivity analyses of payback period PBP




Some tools below are only available to our subscribers or users with an online account.

Related Content

Customize your page view by dragging and repositioning the boxes below.

Related Journal Articles
Related eBook Content
Topic Collections

Sorry! You do not have access to this content. For assistance or to subscribe, please contact us:

  • TELEPHONE: 1-800-843-2763 (Toll-free in the USA)
  • EMAIL: asmedigitalcollection@asme.org
Sign In