A multigrid numerical solution algorithm has been developed for the laminar (Stokes) flow of a compressible medium in a thin film. The solver has been applied to two model problems each representative of lubrication problems in a specific way. For both problems the solutions of the Stokes equations are compared with the solutions of the Reynolds equation. The configurations of both model problems were chosen such that based on the ratio film thickness to contact length (H/L) the difference between the Reynolds and the Stokes solutions will be very small, so the geometry of the gap itself does not lead to a significant cross film dependence of the pressure. It is shown that in this situation the compressibility can still lead to a cross-film pressure dependence which is predicted by the Stokes solution and not by the Reynolds solution. The results demonstrate that limitations exist to the validity of the Reynolds equation related to the compressibility of the medium.

Issue Section:
Technical Papers
Keywords:
film flow, compressible flow, flow simulation, laminar flow, lubrication, mechanical contact, machine bearings, compressibility, viscosity
Topics:
Density, Lubrication, Pressure, Cavitation, Thin films, Flow (Dynamics), Compressibility, Viscosity, Fluids, Geometry
1.
Reynolds
,
O.
,
1886
, “
On the Theory of Lubrication and Its Application to Mr. Beauchamps Tower’s Experiments, Including an Experimental Determination of the Viscosity of Olive Oil
,”
Philos. Trans. R. Soc. London
,
177
, pp.
157
–
234
.
2.
Sun
,
D. C.
, and
Chen
,
K. K.
,
1977
, “
First Effects of Stokes Roughness on Hydrodynamic Lubrication
,”
J. Lubr. Technol.
,
99
pp.
2
–
9
.
3.
Phan-Thien
,
N.
,
1981
, “
On the Effects of the Reynolds and Stokes Surface Roughnesses in a Two-Dimensional Slider Bearing
,”
Proc. R. Soc. London, Ser. A
,
377
, pp.
349
–
362
.
4.
Myllerup, C. M., and Hamrock, B. J., 1992, “Local Effects in Thin Film Lubrication,” Proceedings of the 19th Leeds Lyon conference on tribology.
5.
Myllerup
,
C. M.
, and
Hamrock
,
B. J.
,
1994
, “
Perturbation Approach to Hydrodynamic Lubrication Theory
,”
ASME J. Tribol.
,
116
, pp.
110
–
118
.
6.
Noordmans, J., 1996, “Solutions of Highly Anisotropic Stokes Equations for Lubrication Problems,” ECCOMAS 96.
7.
Scha¨fer, C. T., Giese, P., and Woolley, N. H., 1999, “Elastohydrodynamically Lubricated Line Contact Based on the Navier-Stokes Equations,” Proceedings of the 26th Leeds Lyon conference on tribology.
8.
Odyck van, D. E. A., 2001. “Stokes Flow in Thin Films,” Ph.D. thesis, University of Twente, The Netherlands.
9.
Odyck van
,
D. E. A.
, and
Venner
,
C. H.
,
2003
. “
Stokes Flow in Thin Films
,”
ASME J. Tribol.
,
125
, pp.
1
–
14
.
10.
Bair
,
S.
,
Khonsari
,
M.
, and
Winer
,
W. O.
,
1998
, “
High-Pressure Rheology of Lubricants and Limitations of the Reynolds Equation
,”
Tribol. Int.
,
31
)(
10
), pp.
573
–
586
.
11.
Batchelor, G. K., 2000, An Introduction to Fluid Dynamics, Cambridge University Press, UK, ISBN 0521663962.
12.
Langlois, W. E., 1964, Slow Viscous Flow, The Macmillan Company, New York.
13.
Constantinescu, V. N., 1969, Gas Lubrication, ASME, New York.
14.
Dowson
,
D.
, and
Taylor
,
C. M.
,
1979
, “
Cavitation in Bearings
,”
Annu. Rev. Fluid Mech.
,
11
, pp.
35
–
66
.
15.
Elrod
,
H. G.
,
1981
, “
A Cavitation Algorithm
,”
ASME J. Lubr. Technol.
,
103
, pp.
350
–
354
.
16.
Delannoy, Y., and Kueny, J. L., 1990, “Two-Phase Flow Approach in Unsteady Cavitation Modeling,” Cavitation and Multiphase Flow, 98, ASME FED, pp. 153–158.
17.
Hoeijmakers, H. W. M., Janssens, M. E., and Kwan, W., 1998, “Numerical Simulation of Sheet Cavitation,” Proceedings of the third international symposium on cavitation, Grenoble, France.
18.
Kubota
,
A.
,
Kato
,
H.
, and
Yamaguchi
,
H.
,
1992
, “
A New Modeling of Cavitating Flows: A Numerical Study of Unsteady Cavitation on a Hydrofoil Section
,”
J. Fluid Mech.
,
240
, pp.
59
–
96
.
19.
Jakobsson, B., and Floberg, L., 1957, “The Finite Journal Bearing, Considering Vaporization,” Trans. Chalmers Univ. Tech., Go¨teborg, 190.
20.
Olsson, K., 1965, “Cavitation in Dynamically Loaded Bearings,” Trans. Chalmers Univ. Tech. Go¨teborg, 308.
21.
van Wijngaarden
,
L.
,
1972
, “
One Dimensional Flow of Liquids Containing Small Gas Bubbles
,”
Annu. Rev. Fluid Mech.
,
4
, pp.
369
–
396
.
Copyright © 2003
 by ASME
You do not currently have access to this content.